Hi All,
Trying to strip down my 1973 1L for painting, but stuck at getting the doors off, do I try and undo the hinge bolts that go into the door, or try to get at the hinge bolts into the car body ?
I've removed the stays so the doors open out almost 90 degrees, but still having a lot of trouble. Is the hinge pin removable ? any advice is appreciated
Des
Welcome to the Irish Mini Owners Club Forum. Keep an eye out of on coming events!!!!
How do I get the bloody doors off !
Moderators: spud1979, The Marcos Graveyard, Moderators
-
daniel garry
- NON Member
- Posts: 841
- Joined: Mon Jun 15, 2009 1:20 pm
- Whats your location?: cavan
- Region: Western
- What Minis have you?: 1996 BRG mayfair 1275 auto-lyin up now
1990 1l city-daily driver
1993 cooper spi-completly stripped and upside down!
the long term project(advantage) courtesy of mr skelly!!
rotten shell-found a floor repair panel in the boot tho! - Contact:
Re: How do I get the bloody doors off !
well if you go for the nuts holding the hinge to the body you probably will end up shearing off the bolt. its not as easy but if you go for the hinge to door you're less likely to shear it
-
keith
- NON Member
- Posts: 2118
- Joined: Tue Jul 18, 2006 11:15 pm
- Whats your location?: Dún Laoghaire, Dublin
- Region: Eastern
- What Minis have you?: '93 SPi cooper
- Location: Dún Laoghaire, Dublin
- Contact:
Re: How do I get the bloody doors off !
don't do it this way: http://www.youtube.com/watch?v=8g_GeQR8fJo
Signature still awaiting top-coat and lacquer....
-
woody
- IMOC Paid Member
- Posts: 2838
- Joined: Mon Feb 07, 2005 11:55 pm
- Whats your location?: Drogheda
- Region: Eastern
- What Minis have you?: Traveller
Turbo
Hornet
Equinox
MINI Clubman - Location: LOUTH
- Contact:
Re: How do I get the bloody doors off !
Personally I always remove the hinges from the body. Clean nuts with wire brush then leave soak in WD40. Using a 6 sided 7/16 socket tapped home with a hammer turn it back and forth all the way out. If you do shear a stud its posable to repair when you have it out.
TECHNICAL MODERATOR
-
beadles
- NON Member
- Posts: 93
- Joined: Sat Mar 15, 2008 12:04 pm
- Whats your location?: " half way between panic and sheer blind terror"
- Region: Eastern
- What Minis have you?: "RUSTY" an 88 city in garage undergoing surgery . "Beadles" A late 80's early 90's City Automatic
Shell on the driveway, some of him in the garage more in the shed and the rest of him
in the attic - Location: Mount Merrion Co. Dublin
- Contact:
Re: How do I get the bloody doors off !
You could blow them off! 
Is it a coincidence that mini and money start with the same letter? 'cause if you have the first you sure better have lots of the other
-
mgb1978
- NON Member
- Posts: 316
- Joined: Wed Jun 17, 2009 4:43 pm
- Whats your location?: Co. Limerick
- Region: Southern
- What Minis have you?: 1976 saloon , 1275cc, White with black roof. Converted to Discs on the cheap so stuck with 12"s for now.
- Contact:
Re: How do I get the bloody doors off !
Woody's method is the best.
And if one or two (or three) of the hinge studs snap when you are removing the nuts, it's fairly easy to drill out the hinge and weld in a new bolt.
And if one or two (or three) of the hinge studs snap when you are removing the nuts, it's fairly easy to drill out the hinge and weld in a new bolt.
Re: How do I get the bloody doors off !
Thanks Woody, and everyone else, went at them from under the wheel arch, only 1 snapped off and not too bad a job as I was expecting.
Who is online
Users browsing this forum: No registered users and 29 guests
